Optimizing C:N Ratio, C:P Ratio, and pH for Biosurfactant Production by Pseudomonas fluorescens
Journal of Advances in Microbiology · pp. 1–14 · Published 20 Dec 2017
10.9734/JAMB/2017/38199Abstract
Aim: To optimize the combination of selected culture medium parameters so as to achieve maximum biosurfactant production from Pseudomonas fluorescens. Study Design: (1) Culturing P. fluorescens for biosurfactant production using a glycerol-mineral salt media with variations in ratio, carbon and phosphorus ratio (C:P ratio), and pH, (2) Screening for biosurfactant activity, (3) use of Response Surface Methodology in determining the combination of the factors that will lead to maximum biosurfactant production. Place and Duration of Study: Department of Microbiology, Faculty of Science, University of Port Harcourt, Nigeria, between September 2016 and June 2017. Methodology: Pseudomonas fluorescens was cultured for biosurfactant production using glycerol-mineral salt media with variations in carbon and nitrogen ratio(C:N ratio), C:P ratio, and pH. Combination of these factors was optimized via the use of Response Surface Methodology. The range of values of the factors investigated was C:N: 20–60, C:P: 10–16, pH: 5.5–8.5. Fifteen experimental runs were carried out. Results: At the end of the experimental runs, the surface tensions of the culture broths ranged from 30.66 – 51.90 mN.m-1. The surface tensions were fitted into the generalized polynomial model for 3-factor design. The model was worked out to be Y = 296.5533 – 34.4456X1 + 0.602833X2 – 23.4019X3 – 0.0545 X1X2 + 1.088889X1X3 + 0.020417 X2X3 + 1.663333X12 – 0.00596X22 + 0.551944X32. Prediction profiles generated from this model showed that the lowest surface tension, indicating maximum biosurfactant production, was achievable at a combination of pH 5.5, C:N = 20, and C:P = 16. Use of this combination for biosurfactant production resulted in reduction of the surface tension of the broth culture from 60.04 mN.m-1 to 30.64 mN.m-1. This almost tallied with the predicted value of 30.57 mN.m-1. Conclusion: The optimized combination avoided wastage of the carbon source. It is thus economical to carry out optimization procedures before proceeding to commercial production of biosurfactants.
References (25)
- 1 Microbial Degradation of Petroleum Hydrocarbon Contaminants: An Overview [DOI]
- 2 Microbial biosurfactants production, applications and future potential [DOI]
- 3 Emergence of Antibiotic-Resistant Pseudomonas aeruginosa : Comparison of Risks Associated with Different Antipseudomonal Agents [DOI]
- 4 Pseudomonas aeruginosa biosurfactant production in continuous culture with glucose as carbon source [DOI]
- 5 Screening Concepts for the Isolation of Biosurfactant Producing Microorganisms [DOI]
- 6 Biosurfactant production by a soil pseudomonas strain growing on polycyclic aromatic hydrocarbons [DOI]
- 7 Evaluation of different carbon and nitrogen sources in production of biosurfactant by Pseudomonas fluorescens [DOI]
- 8 Biosurfactants in industry [DOI]
- 9 Recovery of Rhodococcus biosurfactants using methyl tertiary-butyl ether extraction [DOI]
- 10 Introduction To The Chemical Analysis Of Foods
- 11 Synthesis of Biosurfactants and Their Advantages to Microorganisms and Mankind [DOI]
- 12 Production of biosurfactants from Pseudomonas aeruginosa PA 1 isolated in oil environments [DOI]
- 13 Biosurfactant production by Pseudomonas fluorescens 378: growth and product characteristics [DOI]
- 14 Effect of pH and salinity on the emulsifying capacity and naphthalene solubility of a biosurfactant produced by Pseudomonas fluorescens [DOI]
- 15 ISOLATION AND PRODUCTION OF BIOSURFACTANT FROM PSEUDOMONAS AERUGINOSA ISOLATED FROM IRANIAN SOUTHERN WELLS OIL
- 16 Statistical approach to optimize production of biosurfactant by Pseudomonas aeruginosa 2297 [DOI]
- 17 RESPONSE SURFACE OPTIMIZATION OF BIOSURFACTANT PRODUCED BY Pseudomonas aeruginosa MA01 ISOLATED FROM SPOILED APPLES [DOI]
- 18 Effects of alcohols, anionic and nonionic surfactants on the reduction of pce and tce by zero-valent iron [DOI]
- 19 Isolation, Identification and Antibiogram Study of Pseudomonas Aeruginosa from Cattle in Bangladesh. [DOI]
- 20 Virulence Attributes and Host Response Assays for Determining Pathogenic Potential of Pseudomonas Strains Used in Biotechnology [DOI]
- 21 Enhanced production and characterization of biosurfactant produced by a newly isolated Bacillus amyloliquefaciens USTBb using response surface methodology
- 22 Effect of Different Carbon Sources on the Production of Biosurfactant by Pseudomonas fluorescens Isolated from Mangrove Forests (Pichavaram), Tamil Nadu, India
- 23 Response surface analyses of rhamnolipid production by Pseudomonas aeruginosa strain with two response values [DOI]
- 24 Pseudomonas aeruginosa KVD1 an Efficient Biosurfactant Producing Bacteria Isolated from Krishna Delta Mangrove Sediments [DOI]
- 25 The 100 most important chemical compounds: a reference guide [DOI]
Cited by 16
Shailee Gaur, Suresh Gupta, Prabhat N. Jha · Environmental Technology · 2023
N.A. Jayalatha, C.P. Devatha · Journal of Environmental Management · 2023
Lekiah Pedro Peekate, Happy Boreh · Journal of Applied Sciences · 2019
Alejandra Barbachano‐Torres, Mayra A. López‐Ortega, Mariana Delgado‐García · Journal of Surfactants and Detergents · 2019
Joseph E. Agbaji, Eucharia O. Nwaichi, Gideon O. Abu · AAS Open Research · 2020
Showing 5 of 16 known citations — external sources report more than can currently be individually listed.
Related research
- Modelling and Optimisation of Yoghurt Production from Tigernut (Cyperus esculentus L.) Using Response Surface Methodology (RSM) — shares topic coverage
- Determination of Optimum Processing Conditions for the Proximate Composition and Pasting Characteristics of Flour Made from Parboiled Cassava Chips: A Response Surface Analysis — shares topic coverage
- Process Optimization and Characterization of Gamma Irradiation Induced Variations in Functional Properties of Maize (Zea mays L.) Flour — shares topic coverage
- Optimization of Quinoa Seed Powder for Preparation of Sugarfree Burfi by Response Surface Methodology (RSM) — shares topic coverage
- Optimization of African Breadfruit Based Complementary Food Using Mixture Response Surface Methodology — shares topic coverage
Article metrics
Real usage data collected on this platform.
0
Page views
0
PDF downloads
0
Outbound clicks
16
Citations
Views by country
Approximate, from request IP at view time — not citizenship or institution. Countries with fewer than 5 views are grouped as "Other".
No views recorded yet.
Traffic sources
Referring site, by host.
No traffic recorded yet.
Views and downloads exclude known bots/crawlers. Citations combines this platform's own DOI-resolved index with each external source's own reported total — see Cited by above for individually listed citing works. Last refreshed 0 seconds ago.